Instead of Flaring Natural Gas at Fracked Oil Wells, Use it to Treat Fracking Fluid

by Emil Morhardt

Seems like a good idea. Yael Rebecca Glazer just suggested it in a Masters Thesis in Engineering at the University of Texas at Austin. A major issue with fracking is that sometimes a lot of the fracking fluid that was pumped down the well to create the fractures comes back up, sometimes along with additional “produced” water, sometimes twice as much as was pumped down in the first place. On top of that, it is often so contaminated that it exceeds the capabilities of industrial treatment facilities, so it gets trucked to a nearby injection well and is reinserted. But injection wells are not always handy, and anyway, the water itself would be valuable if it weren’t so polluted. Meanwhile, although a fracked well might producing mainly oil, there is also often a fair amount of natural gas produced; but if there isn’t enough gas to make it economical to capture it and sell it, it is commonly flared—burned right there at the wellhead. This converts the natural gas to CO2 without using the energy released for anything at all. Maybe, thought Ms. Glazer, that free energy could be used onsite to power wastewater cleanup technologies that normally wouldn’t be considered because of their high energy costs. It also occurred to her that since lots of these wells are in the sunny, windy southwestern US, local photovoltaic panels or wind turbines might supply energy as well. This latter option is attractive when there are no convenient transmission lines to take the power offsite, even though solar or wind energy is abundant. Continue reading

Unexpectedly High Methane Concentrations over Shale Gas Fields

by Emil Morhardt

Methane, the main constituent of natural gas (both that from gas wells and from farm operations) is a powerful greenhouse gas, around 30 times more potent than CO2 over the hundred years after it is emitted. It is on the rise, and the culprit might be shale gas development, which utilizes hydraulic fracturing (fracking). Caulton et al. (2014) used an airplane to sample the air above a 2,800-square-kilometer area of the Marcellus shale formation gas fields in Pennsylvania. It was rich in methane, with between 2 and 15 grams heading skyward over each square kilometer every second, the upper limit of which is quite a lot higher than the 5 grams estimated from what was previously known about wellhead methane emissions; the authors suspected that the transient nature of gas leakage might be the reason, making very difficult to come up with an average over time from ground-level measurements. Since they were in an airplane, however, they could circle around areas of high concentrations and pinpoint the source. It turns out that…

Continue reading